Projects

Home

Booster Set Upgrade – Liverpool Apartment Block

Booster Set Upgrade – Liverpool Apartment Block

Booster-Set-Upgarde-Liverpool-Apartment-Block NT Cloke Pumps and Water UK

Location: Liverpool
Service: Booster Set Replacement
Sector: Residential / Multi-Occupancy

The Challenge

An ageing booster set at a Liverpool apartment block was causing repeated water disruptions, leaving tenants frustrated and the building management team dealing with constant callouts. A reliable, modern replacement was urgently needed to restore consistent supply.

Our Solution

NT Cloke engineers attended site to survey, measure and specify the correct system. We supplied and installed a triple-pump variable speed booster set complete with new fittings and full insulation. Every component was selected for performance, efficiency, and ease of maintenance.

The Result

Following commissioning, the new system delivered steady pressure throughout the entire block — keeping tenants supplied and operations running smoothly. The upgrade was completed with minimal disruption on site, thanks to careful planning and coordination by our team.

✅ Full site survey and system specification
✅ Triple-pump variable speed booster installed
✅ Fully insulated and commissioned system

Need a Booster Set Upgrade?

If your property is struggling with low pressure or an unreliable booster system, NT Cloke can help.
We design, supply, and install bespoke water booster solutions across the UK.
Contact our team today for a tailored quote.

You may also like

School Booster Set Inverter Replacement in Leicester | Apprentice Engineering Success | NT Cloke Pumps & Water
04 Jun

Apprentice-Led Inverter Replacement at Leicester School

The Challenge NT Cloke Pumps & Water were called to a local school in Leicester following a fault on the

CONTINUE READING
Emergency Booster Set Repair & Hydrovar Replacement in Birkenhead Hotel | NT Cloke Pumps & Water
02 Jun

Emergency Booster Set Repair for Major Hotel Chain in Birkenhead

The Problem NT Cloke Pumps & Water were called to a major hotel in Birkenhead after a complete failure of

CONTINUE READING
Emergency Heating System Leak Repair at Leicester School | NT Cloke Pumps & Water
28 May

Emergency Heating System Leak Repair at Leicester School

The Problem NT Cloke Pumps & Water were called to a school in Leicester following reports of a leak within

CONTINUE READING
Booster Set Inverter Replacement at Leicester School | NT Cloke Pumps & Water
21 May

Emergency Booster Set Inverter Replacement for Leicester School

When a booster set inverter fails, maintaining a reliable water supply becomes a priority, particularly in environments such as schools

CONTINUE READING
Lowara Booster Pump Replacement at School in Bath | NT Cloke Pumps & Water
19 May

Lowara Booster Pump Replacement for School Water System in Bath

When a booster pump fails in a school environment, a fast and effective response is essential to maintain reliable water

CONTINUE READING
This is from their fb social, i will upload it as a case study :) Solving Low Water Pressure in a London Property 🚰🏙️ Low water pressure can be frustrating — but for one London property owner, it’s now a thing of the past. After being contacted about ongoing pressure issues, our team attended site and carried out testing. The results were clear: the property needed a booster set to deliver consistent, reliable flow. With limited space available, we designed and installed an in-tank booster set with inverter controls — a compact, efficient solution perfect for the property’s needs. Following installation, we took the owner on a walk-around… and let’s just say the smile said it all. ✅ Tailored solution for the property ✅ Fully tested and commissioned ✅ Reliable pressure, every time If you’re battling low pressure in your building — whether residential, commercial or mixed-use — we can design, supply and install the right system for your space. 🚰 Booster Set Upgrade – Liverpool Apartment Block When an ageing booster set repeatedly failed, it left tenants facing water disruptions and ongoing issues. A full upgrade was the only solution. ✅ We surveyed, measured, and specified the correct system ✅ Ordered all parts, fittings, and a new triple pump variable booster ✅ Installed, insulated, and commissioned the system The result? A reliable, efficient booster set that keeps the entire block running smoothly — giving residents the consistent water supply they deserve. A huge effort from our team to deliver a seamless installation with minimal disruption onsite. ⚡ Control Panel Failure – College Site ⚡ We were recently called to a college after a power surge damaged the PCBs in their old Grundfos control panel. With the panel now obsolete and replacement parts unavailable, our engineers had to act quickly. ✅ Temporarily set Pump No.1 as a single pump ✅ Rewired the transducer directly into the inverter ✅ Restored water supply to site 👉 Next steps: we’ll be offering the client two options — either a new control panel compatible with their inverters, or a complete new booster unit. 💡 Installed back in 2006, this set has certainly had its time. An upgrade will deliver improved reliability and efficiency moving forward. 🔧 One of the key strengths of our engineers is that they are multi-skilled and experienced with all makes and models — meaning whatever system you have on site, we can provide a fix and keep your building operational. 🚨 Tank Clean & Chlorination – Leicester Apartment Block 🚨 This week our engineers carried out a full tank clean and chlorination at an apartment block in Leicester – and as the photos show, this one was well overdue. Alongside the clean, we also took post-service samples to ensure everything met the correct standards. 💡 Why does this matter? When tanks are left unchecked, sediment, scale, and bacteria can build up, putting residents at risk and reducing system efficiency. Legionella and other harmful bacteria thrive in poorly maintained systems – a risk no building or facilities manager should ignore. ✅ Cleaned & chlorinated tank ✅ Samples sent for testing ✅ Water supply safe, compliant and efficient ⚠️ A reminder: out of sight should never mean out of mind. Regular tank cleaning is essential for compliance, efficiency, and above all, safety. At NT Cloke Pumps & Water, we handle it all – tank cleans, chlorination's, booster servicing, heating pumps and more – all in one visit. One trusted partner, full peace of mind. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk ✈️ Booster Set Replacement – Heathrow High-Rise 🏢 We were contacted by a customer whose booster set was on its last legs. The controls had failed, leaving the system running constantly on a single pump. As you can see from the picture… it had pumped its last pump! Our engineers arrived on-site, safely isolated the system and carried out the full replacement. The old unit was swapped out for a new inverter-driven booster set, delivering a more reliable and efficient solution. 💡 The result? ✅ Improved efficiency ✅ Energy savings from the pump now switching off when not required ✅ Peace of mind for the customer Another smooth installation completed by the NT Cloke team. 📞 If your booster set is showing signs of age, we can spec, supply and install the right replacement — keeping your building running as it should. 🔧 When Vessels Fail – Why We Always Check the Bigger Picture 💧 We were called out after a customer reported their pumps were constantly running and making a loud banging sound. On inspection, we quickly identified the issue — the vessels had failed, which was stopping the unit from starting and stopping correctly. But here’s the important part: whenever we attend a call-out like this, our engineers don’t just fix the obvious issue. We always carry out a full site inspection and check the condition of the cold water storage tanks. 💡 Why? Because a booster set is only as reliable as the system it’s connected to. Neglected tanks are a hidden risk for contamination, system inefficiency and long-term failures. On this visit, we also arranged and completed a full tank clean and chlorination — more on this in another post. 👉 This is why our clients trust us: we look beyond the immediate fix and make sure everything is taken care of. 📞 Need peace of mind with your pumps and water systems? Speak to NT Cloke Pumps & Water today. 🌊 Tank Clean, Chlorination & Pump Service – London Residential Property 🏠 Last week our team carried out a full tank clean and chlorination at a private residential property in London. As you’ll see in the photos, this tank was well overdue a clean — but it’s not just about the end result, it’s about how we get there: ✅ Extra care in client homes – carpet protection used throughout to keep the property spotless during works. ✅ Thorough cleaning & chlorination – restoring the system to a safe, compliant condition. ✅ Post-service sampling – water samples sent for testing, giving the homeowner peace of mind. ✅ Pump service completed – while onsite, our engineers also serviced the pumps to ensure the whole system was running smoothly. 💡 Why choose two or three different companies when you can work with one team that excels in both water hygiene and pump systems? At NT Cloke Pumps & Water, we deliver the full package — saving clients time, hassle and cost. 👏 Great work from the team once again! 🏫 School Servicing – Summer Preparation for Winter ❄️🔧 Summer holidays aren’t just about rest — they’re also the ideal time for schools to get servicing and maintenance completed while buildings are quieter. Our team recently carried out full school servicing works, making sure systems are in top condition and ready for the winter switch-on and the cold months ahead...now is the time schools should be planning for the winter, as the temperatures begin to drop 💡 Benefits of summer servicing for schools: ✅ Zero disruption to lessons ✅ Early identification of issues before winter demand ✅ Reliable heating & water systems when students return Planning ahead saves schools stress, downtime and costs — exactly why proactive maintenance matters. 🎓 Pressurisation Unit Upgrade – Cardiff Student Block 🏢 When a pump and controls failure caused issues at this busy student accommodation block in Cardiff, the client decided it was the right time for an upgrade. Our engineers specified and installed a new Mikrofill twin pump wall-hung unit, perfectly suited for the site. Thanks to the skill and planning of our team, the upgrade was completed with no downtime — keeping the building fully operational throughout. 💡 Why it matters: ✅ Reliable water system management ✅ Improved efficiency & modern controls ✅ Peace of mind for the client Another seamless project delivered by NT Cloke Pumps & Water. 💧 Booster Set Service & Tank Clean – Residential Property 🏠 This week our team completed a full booster set service and a tank clean & chlorination on a 500-litre tank at a residential property. ✅ The customer opted for our complete package, allowing us to carry out both services in one visit. ✅ Water samples were taken and sent for testing, ensuring everything remains safe, clean and compliant. ✅ Booster set fully serviced for smooth, efficient operation. Choosing a combined package means less disruption, better efficiency and ongoing protection for your water system. 👏 Another great example of how NT Cloke Pumps & Water delivers full-service water hygiene and pump maintenance solutions for homeowners and landlords. 📞 Ready to protect your property? Get in touch today. Inverter Replacement – Birmingham Apartment Block 🏢 When two old drives failed, this Birmingham apartment block was left with just 1 of 3 pumps operational. Our team attended quickly and replaced the faulty inverters, restoring full functionality. ✅ No disruption to water supply – residents had water throughout the works. ✅ Expertise across all makes & models – we can diagnose and resolve issues on any system. ✅ Full testing & commissioning – ensuring long-term reliability. At NT Cloke Pumps & Water, we pride ourselves on finding the best resolution for every client, whether it’s a like-for-like replacement or a system upgrade. 💡 One call, one expert team — whatever the pump or inverter, we’ve got it covered. 🚰 Pump Commissioning for a New Client 🌐 We were recently contacted by a new client who found us online while searching for a company to commission their brand-new pump. After arranging a visit, our team quickly had the system up and running at optimal performance. 👏 🔧 Why pump commissioning matters: • Ensures the pump is set up correctly from day one • Prevents early wear and costly breakdowns • Optimises efficiency and performance • Provides peace of mind that everything is tested and compliant 💡 Why choose NT Cloke? Because we don’t just stop at commissioning. We offer the full package – from installation and servicing to upgrades, chlorination’s and ongoing maintenance. One team, one call. We’re delighted to welcome this client on board and look forward to supporting them with many future projects. 📞 Need commissioning or support with your pumps and water systems? Get in touch today. 🔧 Inlet Change & Tank Clean – Birmingham Apartment Block 💧 This week our engineers carried out an inlet change on a cold water storage tank at an apartment block in Birmingham. But why is changing an inlet so important? 👉 Over time, inlets can wear, corrode or fail, leading to uncontrolled water flow, overfilling, wasted water, and in worst cases, system contamination. Replacing the inlet ensures the tank operates correctly and safely. While on site, we also carried out a full tank clean and chlorination to restore the system to safe, compliant standards — with water samples taken for testing to give residents and property managers complete peace of mind. ✅ Inlet replaced for reliable operation ✅ Tank thoroughly cleaned and disinfected ✅ Samples taken and sent for testing At NT Cloke Pumps & Water, we take a proactive approach. By looking beyond the immediate fix, we help our clients protect their water systems, stay compliant, and avoid costly issues in the future. 📞 Need support with tank maintenance, water hygiene or pump systems? Our team works across the UK, providing complete service packages tailored to your needs. Nature Reserve Booster & Tank Works – Middlesbrough 💧 Our team recently attended a nature reserve in Middlesbrough, where we were called out due to a faulty control board on the booster system. Thanks to our engineers’ expertise (and fully stocked vans!), we were able to replace the faulty board on-site during the same visit — no delays, no disruption. During our inspection, we discovered that the grey water tanks, which feed all the toilets on-site, had never been serviced since installation. We carried out a full tank clean and chlorination, as well as a booster service to bring the system back to a safe and efficient standard. ✅ Faulty control board replaced on-site ✅ All Booster sets on site were fully serviced ✅ Grey water tanks cleaned, chlorinated & tested ✅ System restored to safe, compliant condition ✅ This client has now taken the option for ongoing support with NT Cloke At NT Cloke Pumps & Water, we’re proud to go the extra mile — offering reactive and planned maintenance that keeps even the most complex sites running smoothly. 📞 From nature reserves to high-rise apartments, we deliver full pump and water hygiene services across the UK. Out-of-Hours Panel Replacement – NHS Hospital, Midlands 💧 When the call comes in from a hospital, there’s no time to waste — and our team were on it straight away. We attended an NHS hospital in the Midlands after being contacted about a faulty control panel affecting the water system. To minimise impact on staff and patients, we completed all works out of hours, isolating the water at 4:30am and having the new panel installed and running in no time. ✅ Out-of-hours response ✅ Full panel replacement ✅ Minimal disruption to hospital operations At NT Cloke Pumps & Water, we know the importance of keeping critical facilities like hospitals running — safely, smoothly, and without interruption. Our engineers’ expertise and planning mean even complex jobs are handled efficiently and with care. 👏 Another example of our team’s commitment to reliability and service excellence. Tank Clean & Chlorination – Empty Office Block, Islington, London 💧 Even when a building isn’t in use, water systems don’t stop — and that’s where potential problems can begin. Our team recently completed a pump service and full clean and chlorination of a 500-litre tank at an empty office block in Islington, ensuring the system is safe, clean, and ready for future tenants. 💡 Why it matters: When buildings sit vacant for extended periods, stagnant water can create the perfect environment for harmful bacteria such as Legionella. Regular maintenance and cleaning are essential to prevent contamination and keep systems compliant. ✅ Full pump service ✅ Tank clean & chlorination ✅ System now safe and ready for re-occupation At NT Cloke Pumps & Water, we help property managers and landlords safeguard their assets — preventing issues before they arise and ensuring every system meets hygiene and safety standards. 📞 If you manage an empty or low-occupancy building, now’s the time to act. theres a lot haha, all good for SEO though These are showing red on elementor :( 🔥 New Lowara Twin-Head Heating Circulator Installation – Wales 🏢 Our team recently supplied, installed and commissioned a Lowara twin-head heating circulator pump at a building in Wales, ensuring reliable heating performance just in time for the colder months ahead. 💡 Why choose a twin-head circulator? ✅ Built-in redundancy – ensures heating continuity if one head fails ✅ Improved efficiency & reduced downtime ✅ Ideal for commercial and residential buildings alike At NT Cloke Pumps & Water, we’re trusted nationwide to install, service and commission heating pumps and circulators across all makes and models. 📞 Need a system upgrade or new installation? Get in touch with our team today. 🔧 Submersible Pump Replacement – Cambridge Student Accommodation 🏢💧 Our team recently attended a student accommodation block in Cambridge to carry out a supply and installation of a new submersible pump within a Lowara Resfix residential booster system. ✅ The new pump was installed, connected and fully commissioned ✅ Water pressure restored to full performance ✅ Minimal disruption to residents thanks to our quick turnaround At NT Cloke Pumps & Water, we work with all makes and models of booster systems nationwide and provide efficient, reliable solutions for student blocks, apartments, hotels and commercial buildings. If your booster system is underperforming or showing signs of failure, our team can diagnose, supply, install and commission — all in one visit. 📞 Need support? 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk 🔧 Flooding Issue Resolved – Commercial Office Block 🌊 We were recently called to a large commercial office complex in Nottingham following reports of continuous leaks and flooding in the plant room. 🔍 Initial Findings: Our engineers quickly identified the issue — the old weighted Keraflo valve had failed and was no longer stopping the flow once the tank was full, leading to repeated overflow and water damage. 🛠 Our Solution: On our return visit, our team: Removed the faulty Keraflo valve Supplied and installed a new drop-arm ball valve Fully reconnected, set and tested the system ✅ Result: System now functioning correctly and the client has peace of mind knowing the flooding risk has been eliminated. If your plant room is experiencing recurring leaks or flooding, it could be down to a faulty valve — don’t wait until it becomes a major problem. 📞 0116 3735496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk 🏢 Tank Clean & Chlorination – Apartment Block, Derby 💧 Our team recently completed a full tank clean and chlorination at an apartment block in Derby, helping ensure residents’ water remains safe, clean and compliant. For property management companies, this kind of maintenance isn’t just a box to tick — it’s essential for: 💧 Preventing the build-up of harmful bacteria like Legionella 🔧 Keeping systems running efficiently 🏠 Protecting residents and maintaining compliance with health regulations At NT Cloke Pumps & Water, we work with management companies across the UK to deliver proactive maintenance that keeps properties safe and systems reliable — saving time, money and stress in the long run. 📞 Stay ahead of issues before they start — book your tank clean today.📞 0116 3735496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk 💧 Onsite Mechanical Seal Replacement – Leicester Apartment Block 🏢 When a cleaner discovered water leaking from the plant room, our team was called out straight away. Upon arrival, we quickly identified the issue — one of the pumps had a failed mechanical seal. ✅ Pump isolated and leak stopped immediately ✅ Area fully cleaned and wet-vacced (no more puddles!) ✅ Replacement part sourced overnight ✅ Full onsite strip-down, seal replacement, and pump repair completed the next day The result? The system is now back up and running on both pumps — leak-free and fully operational. At NT Cloke Pumps & Water, we pride ourselves on quick response, effective problem-solving, and getting sites back to full performance with minimal disruption. 📍 Leicester 📞 0116 3735496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk 🔧 Onsite Commissioning – Pressurisation Unit Setup in London 💧🏙️ A smooth commissioning can make all the difference — and our team recently carried out full setup and commissioning of a pressurisation unit on a London building site. Our engineers ensured everything was completed to the highest standard: ✅ Checked installation & pipework ✅ Full system operation checks ✅ Function testing ✅ System set up to run exactly as designed ✅ Final sign-off with all certificates handed over to the customer Commissioning isn’t just a box to tick — it’s essential for long-term performance, system protection and avoiding early faults. Another project handed over with confidence and a very happy client. Pressurisation Unit Upgrade at a Leicester School – Featuring Apprentice Progress! 🏫💧 A great job from the team this week — and an even prouder moment for us as we watched our apprentice, Karn, take the lead on a real installation under the guidance of our senior engineers. We attended a Leicester school to replace a faulty pressurisation unit. The old system was removed, and a brand-new Mikrofill 3 was supplied, fitted and fully commissioned on-site. Here’s what was completed: ✅ Old faulty unit safely removed ✅ New Mikrofill 3 installed ✅ Full commissioning & system setup ✅ Apprentice Karn gaining hands-on experience throughout Seeing our apprentices get real-world exposure like this — supported by our experienced engineers — is exactly how we build confidence, knowledge and long-term skill. 👏 Great work, Karn — keep it up! At NT Cloke Pumps & Water, we’re committed not only to delivering quality work but also to developing the next generation of engineers. 💧 18,000L Tank Clean & Chlorination – Hospital in the Midlands 🏥 Trusted by those who cannot afford to take risks. This past week, we carried out a full clean and chlorination on an 18,000-litre split tank for a first-time customer at a hospital in the Midlands — and we’re proud to now be supporting another critical healthcare site. In environments like hospitals, water hygiene isn’t just maintenance — it’s patient safety. A clean, compliant system helps prevent bacteria growth, protects vulnerable individuals and ensures the facility remains fully operational. 🔍 Why this work is so important in healthcare: ✔️ Reduces risk of Legionella and other harmful bacteria ✔️ Ensures safe water for staff, patients and visitors ✔️ Protects large-scale systems from contamination ✔️ Helps hospitals stay compliant with strict regulations ✔️ Prevents costly emergencies and disruption to patient care This job included: 🔹 Full clean and chlorination of both split tanks 🔹 Visual inspection of all internal components 🔹 Post-clean water sampling to confirm safety and compliance 💙 We’re proud to be trusted by hospitals, healthcare providers and NHS sites across the UK — where reliability, response times and attention to detail truly matter. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Big Home Booster Replacement – Rural Birmingham Property 🏡✨ We were recently contacted by a homeowner following a full house refurbishment at a beautiful rural property outside Birmingham. Despite the upgrades, they were still facing major water pressure issues. After attending site, it became clear why — the inherited booster unit was undersized, unreliable and never suitable for a property of this scale. We carried out a full assessment and presented a range of replacement options. The customer opted for a brand-new booster set complete with a new tank, full repipe and a bypass installation to futureproof the system. Our team moved quickly to order, build and install the new setup — transforming the property’s water performance. 🔧 What we delivered: Full system investigation Supply & installation of new booster set and tank Full repipe of the system for improved flow New bypass added for resilience & easier maintenance Complete mechanical & electrical installation System commissioning & performance testing The result? ✅ Excellent water pressure throughout the home ✅ A reliable, efficient system built to last ✅ A delighted customer — with everything ready for hosting over 20 guests this Christmas 🎄 If you're experiencing low pressure or need expert support with your domestic booster system, our team is here to help. ✈️ Pump Commissioning at an RAF Base 🔧 NT Cloke Pumps & Water were invited to commission new Grundfos pumps at an RAF base — a clear demonstration of the trust placed in our engineers to work on critical infrastructure. Commissioning isn’t just a final tick-box exercise. It’s a vital step that ensures: ✅ The pumps are installed correctly ✅ Performance is fully optimised ✅ All protections and controls function exactly as intended ✅ The system operates safely, reliably, and efficiently from day one For sites like RAF bases — where resilience, safety and reliability are non-negotiable — proper commissioning is essential. Our team carried out full setup, testing and verification to ensure the system is ready for long-term performance. Being trusted to work on environments like this speaks volumes about the expertise, professionalism and consistency of our engineers. 👏 A great job by the team. If you need commissioning support for Grundfos, Lowara, Wilo or any pump system, we’re here to help — nationwide. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #PumpCommissioning #Grundfos #RAFBases #EngineeringExcellence #WaterSystems #FacilitiesManagement #NTClokePumpsAndWater Next one coming up, - 🚨 DAB ESYBOX – Common Faults Homeowners Shouldn’t Ignore 🚨 Got a DAB ESYBOX at home? Some of the most common call-outs we attend point to vessel failure or a non-return valve (NRV) issue. ⚠️ Warning signs to look out for: * Hot water coming from cold taps * Pump running constantly and never switching off * Pressure fluctuating at taps and showers * Noisy operation or poor performance These issues are often caused by failed internal vessels or passing NRVs — both critical components of the system. 🔧 Recent job: We attended a property and carried out a vessel replacement, restoring correct operation and stable pressure. 💡 Why regular checks matter: Left unchecked, these faults can lead to pump damage, higher energy use and unreliable water pressure. If you recognise any of these signs, it’s time to act. 📞 Get in touch with NT Cloke Pumps & Water — we service, repair and support DAB ESYBOX units and all domestic booster systems nationwide. #HomeBoosters #DABESYBOX #WaterPressure #HomeMaintenance #PumpServicing #DomesticWaterSystems #NTClokePumpsAndWater 🚨 Rapid Response Heating Pump Repair – Business Kept Open 🔧 We were recently contacted by a panicked customer reporting a noisy and leaking heating pump, with real concern it could force the closure of their working premises — especially during the colder months. Our team acted fast. By reviewing photos and videos sent over, we quickly identified the likely faults and arranged the required parts without delay. 🛠 On-site repairs carried out: • Full pump strip-down • Bearing replacement • Mechanical seal replacement • All works completed on site, minimising downtime The result? ✅ Heating system restored ✅ No closure required ✅ Business kept fully operational The customer was delighted with both the speed of response and the quality of work, knowing their premises could continue running without disruption. This is exactly why rapid diagnosis, stocked parts and experienced engineers matter — especially when heating systems fail during winter. 📞 Need urgent pump support? We’re ready to help. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #EmergencyCallOut #HeatingPumps #PumpRepair #BusinessContinuity #FacilitiesManagement #WinterPreparedness #OnSiteRepairs #NTClokePumpsAndWater 🔧 Boxing Day Call-Out – Water Restored Without Delay 💧 Support doesn’t stop because it’s a bank holiday — and neither do we. On Boxing Day, our team received a call from one of our existing customers reporting no water on site. The booster set had gone down and the fault was showing on the control screen. Thanks to clear communication from site and our familiarity with the system, we were able to act fast. A quick trip to the workshop to collect the required parts and we were back on site. 🛠️ What we did: Diagnosed the fault Supplied and fitted a new control board Recommissioned the booster set Water restored quickly and safely This is exactly the level of support our clients expect — any time of year, when it matters most. If you’re looking for a pump partner that’s reliable, responsive and already understands your systems, we’re here to help. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk #EmergencyCallOut #BoosterSet #FacilitiesManagement #WaterSystems #ReliableSupport #NTClokePumpsAndWater 🚍 Tank Clean & Chlorination + Booster Service – St Margaret’s Bus Station, Leicester 💧 Our team recently completed a full tank clean and chlorination on Tanks 1 and 2 at St Margaret’s Bus Station in Leicester, alongside a full booster set service — ensuring the site remains safe, compliant and operating as it should. 🧪 Water Sampling Completed As part of the works, we also took 4 water samples: ✔️ 2 x Legionella samples ✔️ 2 x TVC (Total Viable Count) samples These have been sent off for testing to confirm water quality and compliance, giving the client complete peace of mind. 🔧 Why this matters High-footfall public locations like bus stations rely on safe, well-maintained water systems. Regular tank cleaning, chlorination and booster servicing: • Helps prevent harmful bacteria such as Legionella • Keeps water systems compliant with regulations • Protects equipment and extends system lifespan • Reduces the risk of unexpected failures or downtime 💡 One team, complete solution By handling both the water hygiene and booster servicing in one visit, we minimise disruption and simplify maintenance for our clients — something we pride ourselves on. 📍 Leicester | Public Transport Infrastructure 👏 Great work from the team once again. 📞 Need support with tank cleaning, sampling or pump systems? Get in touch with NT Cloke Pumps & Water today. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #WaterHygiene #TankCleaning #LegionellaControl #BoosterSet #FacilitiesManagement #PublicInfrastructure #Leicester #Compliance #BuildingMaintenance #NTClokePumpsAndWater 🔧 Pump Inspection & Safe Removal – Problem Identified and Resolved We were contacted by a customer experiencing ongoing issues with a pump that required a full inspection. Upon attending site and carrying out a detailed survey, our engineers identified that the pump was located in a very tight and awkward space. To properly investigate the fault, the pump needed to be safely removed. This was no issue for our team. Working alongside a specialist lifting company, we returned to site and safely removed the pump without placing anyone at risk. Once removed, we carried out a full strip-down and investigation, identified the root cause of the problem, and completed the necessary repairs to rectify the issue. 💡 This job highlights the importance of doing things the right way — safely, professionally and with the correct support in place. If you’re dealing with a difficult installation or ongoing pump issues, our team has the experience and resources to help. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #PumpInspection #PumpRepairs #FacilitiesManagement #BuildingMaintenance #SafeWorking #EngineeringSupport #CommercialPumps #PlantroomWorks #UKEngineering #NTClokePumpsAndWater 🔧 Pump & Inverter Replacement – Student Accommodation, Birmingham 🏢 Our team recently completed a pump and inverter replacement on a 5-pump booster set at a large student accommodation block in Birmingham. Following issues on site, we attended, assessed the system and carried out targeted replacements to restore full performance and reliability — keeping disruption to residents to a minimum. 💡 Why this matters: * Multi-pump systems need careful diagnosis * Correct inverter setup is critical for system balance * Experience across all makes & models avoids unnecessary full replacements 🔧 Any Make. Any Model. Any Size. From single domestic boosters to large multi-pump systems, we work across all manufacturers and all project sizes — which is why clients trust us with critical sites like student accommodation. 📞 Need support with pumps or inverters? We’re here to help. 📧 info@ntclokepumpsandwater.co.uk 📞 0116 373 5496 🌐 www.ntclokepumpsandwater.co.uk #Armstrong #PumpReplacement #InverterReplacement #StudentAccommodation #FacilitiesManagement #BoosterSets #BuildingMaintenance #AnyMakeAnyModel #NTClokePumpsAndWater next case study - 🔧 Noisy Pump? Don’t Ignore It 🔧 Student Accommodation | Birmingham We were recently called to a student block in Birmingham after reports of a noisy pump. On inspection, the issue was clear — both drive-end and non-drive-end bearings had failed. Our engineers attended site, stripped the pump and replaced the bearings, restoring smooth and quiet operation. 💡 Why this matters: Noise is often the first warning sign of a bigger failure. Left unchecked, bearing issues can lead to seized pumps, overheating motors and unplanned downtime — especially critical in buildings like student accommodation. 🏢 Who we help: We support all sectors — student accommodation, schools, hotels, commercial buildings, residential blocks and more. If you hear unusual noise from a pump, it’s time to act. 🔧 Early intervention saves time, cost and disruption. 📞 Concerned about a noisy pump? Get in touch today. 📧 info@ntclokepumpsandwater.co.uk 📞 0116 373 5496 🌐 www.ntclokepumpsandwater.co.uk #NoisyPump #PumpRepair #BearingReplacement #StudentAccommodation #FacilitiesManagement #BuildingMaintenance #PreventativeMaintenance #NTClokePumpsAndWater 🔧 Non-Return Valve Replacement | Restaurant – Cardiff City Centre When a booster pump won’t shut down, it’s often a valve issue — and that’s exactly what we found here. The problem: The non-return valve internals had completely failed, allowing system pressure to flow back into the tank. This caused the single pump booster set to run continuously, placing unnecessary strain on the system. What we did: Removed the failed valve and installed a new non-return valve, restoring correct system operation and preventing reverse flow back into the tank. The result: ✔ Correct system pressure maintained ✔ Pump operation returned to normal ✔ Reduced wear on pump components ✔ Improved system reliability 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #NonReturnValve #BoosterSets #PumpRepairs #BuildingMaintenance #FacilitiesManagement #HospitalityMaintenance #NTClokePumpsAndWater 🔧 Bearing & Seal Replacement | Booster Pump Repair When bearings or seals begin to fail, performance, efficiency and reliability quickly suffer. The problem: Wear to the pump bearings and seals was causing reduced efficiency and risk of further mechanical damage if left unaddressed. What we did: Carried out a bearing and seal replacement, stripping down the pump, replacing worn components and rebuilding the unit to manufacturer standards. The result: ✔ Smooth, quiet pump operation ✔ Restored efficiency ✔ Reduced risk of leaks and mechanical failure ✔ Extended service life of the pump 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk 🔧 Booster Upgrade & Tank Improvement – Liverpool Apartment Block 🏢 Following an initial call-out to a failed booster set at a Liverpool apartment block, our engineers quickly identified a second critical issue — the existing water tank installation was incorrect, leading to stagnant water (as shown in the photos). 💡 Our Solution: To resolve both issues properly, we carried out a full upgrade of the booster set and installed a new CAT 5 compliant water tank, ensuring correct water movement and improved hygiene. 🛠️ How We Managed the Works: * Installed a temporary bypass during the day to keep water on for residents * Completed the full booster replacement and tank installation * Carried out full commissioning to ensure the system operates as it should The result? ✅ Improved water quality ✅ Reliable pressure and performance ✅ A future-proof system built to current standards This project highlights why a full system review is essential — not just fixing the obvious fault, but addressing underlying issues that can cause long-term problems. 📞 Need support with booster sets or tank installations? We work across the UK and manage all makes and models. Get in touch today. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #BoosterSet #WaterTanks #FacilitiesManagement #ApartmentLiving #Liverpool #WaterHygiene #BuildingMaintenance #NTClokePumpsAndWater Heating Pump Replacement – Office Block Back Up & Running We were recently contacted by one of our customers after a failed heating pump caused disruption to a busy office block. With heating affected, a fast response was critical. Our team quickly sourced a suitable replacement pump and arranged for it to be delivered to site without delay. As soon as the pump arrived, our engineers attended site, removed the failed unit and supplied and installed a new variable-speed heating pump. The system was recommissioned and tested, with heating restored promptly — keeping disruption to a minimum and the building fully operational. Another example of how quick action, the right stock, and experienced engineers make all the difference. A very happy customer and a smooth outcome all round. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk sounds great! here's the next one, Heating Pump Upgrade – School, Birmingham 🏫 The first job of the day was an early start — getting onsite before the kids arrived to install a brand-new Lowara circulator pump. That’s how school works should be done. Quietly. Efficiently. Without disruption. 💡 Why schools are getting us in now: As we move through the colder months, heating systems are under more pressure. Planned upgrades now prevent breakdowns during term time — when heating failures simply aren’t an option. Our team is currently busy across multiple sites in Birmingham, supporting schools with: ✔ Pump upgrades ✔ System improvements ✔ Servicing & maintenance ✔ Planned preventative works We work with all makes and models — and we source, supply, install and maintain everything in-house. One team. One solution. No downtime for students. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk Thankyou, ready for the next one - Booster Set Upgrade – Severn Trent Project 💧 Severn Trent reached out to NT Cloke Pumps & Water to support with a long overdue upgrade to a failing booster set — critical to the site’s operation. Following a detailed site visit, our team designed and built a brand-new upgraded skid alongside our trusted pump suppliers. This set plays a vital role in clearing mine water and acts as the heartbeat of the complex building’s process. A secondary booster is used to keep the pump chambers clean and protect the seals — so reliability was absolutely key. ⏱ We had just 24 hours to complete the changeover. Designed. Built. Installed. Commissioned. All delivered within the required timeframe — ensuring the process remained protected and operational. One very relieved client — and discussions already underway about further upgrades across additional sites. At NT Cloke, we manage projects from: ✔ Initial site visits & surveys ✔ Bespoke design & build ✔ Mechanical & electrical installation ✔ Full commissioning & handover From standard replacements to specialist bespoke projects — we build solutions around what our clients need. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk thank you, here's the next - Booster Set Upgrade – Midlands Apartment Block 🏢 We were called out to a failed booster set at a Midlands apartment block that had been limping along on just one pump — down on flow and pressure, and well overdue an upgrade. After discussing the available options with the client, they chose to move forward with a new, energy-efficient booster set designed to improve reliability and performance long-term. From service and diagnosis through to supply and full installation, everything was carried out by our in-house team. ✔ Fault diagnosed ✔ Upgrade options provided ✔ New energy-efficient system supplied ✔ Full mechanical & electrical installation ✔ Commissioned and tested The result? ✅ Consistent pressure restored ✅ Improved system efficiency ✅ Reduced risk of future failures ✅ Happy residents At NT Cloke Pumps & Water, we manage the entire process — service, supply, install and ongoing maintenance — all under one roof. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Pump Replacement – Apartment Block | Birmingham A major pump replacement project completed for a residential apartment block in Birmingham. The problem: One of the main booster pumps had failed, risking disruption to the building’s water supply. What we did: Our engineers attended site to assess the system and organised the replacement of a 190kg booster pump, ensuring the correct equipment and lifting methods were used to safely remove the old unit and install the new one. The solution: ✔ New 190kg pump delivered to site ✔ Old pump safely removed ✔ New unit installed and aligned ✔ System tested and returned to service The result: ✔ Reliable water supply restored ✔ System operating as designed ✔ Minimal disruption to residents Large pumps, tight spaces, and critical systems — another job completed safely and efficiently by the team. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Next up - 🔧 Faulty Ball Valve Replacement | Apartment Block – Birmingham During a routine service visit at an apartment block in Birmingham, our engineers identified a faulty 2” ball valve on the system. The problem: A failing valve within the booster system pipework which required prompt attention to prevent further issues. What we did: The team immediately informed the client and arranged for the required parts. A new 2” ball valve was sourced and our engineers returned to site to carry out the repair. Works carried out: ✔ Inlet isolated to allow safe works ✔ Faulty valve removed ✔ New 2” ball valve supplied and installed ✔ System reopened and fully tested The result: ✔ System returned to normal operation ✔ Booster set checked over and confirmed fully operational ✔ Issue resolved quickly to minimise disruption to the building Another example of identifying issues during servicing and resolving them quickly to keep systems running reliably. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #BoosterSets #PumpMaintenance #BuildingMaintenance #FacilitiesManagement #WaterSystems #Birmingham #NTClokePumpsAndWater 🔧 New Pump Installation & Tank Clean – Call Out To A Farmhouse A recent call out to a farmhouse where the existing system required both a pump upgrade and a full tank clean to restore performance and water quality. The problem: The system was struggling, with visible build-up inside the tank and an ageing pump affecting reliability and pressure. What we did: ✔ Isolated and drained the cold water storage tank ✔ Removed debris and sediment build-up ✔ Cleaned and disinfected the tank ✔ Installed a new booster pump set ✔ Recommissioned and tested the system The solution: A new pump system paired with a fully cleaned tank ensures the system is now operating efficiently and hygienically. The result: ✔ Improved water pressure throughout the property ✔ Clean, hygienic water storage ✔ Reliable system performance restored From rural properties to commercial sites, keeping both pump systems and water storage tanks in top condition is key to long-term reliability. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #PumpInstallation #TankCleaning #WaterSystems #FarmhouseLiving #WaterHygiene #NTClokePumpsAndWate 🔧 Tank Clean, Chlorination & Booster Set Service – Rural Chippenham A recent job carried out at a rural property near Chippenham, where the system required a full tank clean, chlorination, and booster set service to bring everything back up to standard. The problem: Build-up and sediment inside the cold water storage tank, along with a system that needed servicing to ensure reliable performance and water quality. What we did: ✔ Drained and inspected the cold water storage tank ✔ Removed debris and sediment build-up ✔ Carried out a full tank clean and disinfection (chlorination) ✔ Checked and serviced the booster set ✔ Tested system temperatures and performance ✔ Refilled and recommissioned the system The solution: A fully cleaned and disinfected tank, combined with a serviced booster set, ensuring both water hygiene and system reliability. The result: ✔ Clean, safe water storage ✔ Improved system efficiency ✔ Consistent water pressure across the property ✔ Peace of mind for the client Rural properties often rely heavily on stored water systems — keeping tanks clean and systems serviced is essential for both performance and health compliance. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #TankCleaning #Chlorination #BoosterSet #WaterHygiene #PumpEngineers #Chippenham #NTClokePumpsAndWater Booster Set Upgrade – Apartment Block | Birmingham City Centre A recent project in Birmingham city centre, where ongoing issues with an ageing booster set led to repeated callouts and unreliable performance. The problem: The existing fixed-speed booster set had deteriorated significantly, with multiple previous repair attempts and temporary fixes. The system was no longer reliable and was impacting water pressure across the building. What we did: ✔ Full system assessment and fault investigation ✔ Removal of failing booster set ✔ Installation of a new variable speed booster set ✔ All mechanical and electrical works completed in-house ✔ New local electrical isolator installed ✔ Service points and isolation valve added to discharge pipework ✔ Pipework reconfigured, clipped, and fully lagged The solution: Upgraded to a modern variable speed booster set, delivering a smarter, more energy-efficient system with improved performance and long-term reliability. The result: ✔ Consistent water pressure throughout the building ✔ Reduced energy consumption ✔ Cleaner, more serviceable installation ✔ Future-proofed system for easier maintenance When systems are beyond repair, upgrading isn’t just a fix — it’s an investment in performance, efficiency, and reliability. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #BoosterSet #PumpEngineers #Birmingham #WaterSystems #CommercialPlumbing #NTCloke Circulator Pump Replacement – Hotel | Birmingham A recent circulator pump replacement carried out at a hotel in Birmingham, where the existing system was no longer performing efficiently. The problem: The existing circulator pump had deteriorated over time, impacting system performance and reliability. With signs of wear and reduced efficiency, a replacement was required to ensure consistent operation. What we did: ✔ Removal of existing circulator pump ✔ Installation of a new high-efficiency replacement pump ✔ System checks and recommissioning ✔ Ensured correct flow and performance across the system The solution: Upgrading to a modern circulator pump improved system efficiency, reduced energy usage, and restored reliable performance across the hotel’s heating system. The result: ✔ Improved system efficiency ✔ Reliable and consistent circulation ✔ Reduced energy consumption ✔ Minimal disruption to hotel operations Keeping commercial systems running efficiently is key — especially in environments where downtime isn’t an option. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #CirculatorPump #CommercialHeating #Birmingham #PumpEngineers #NTCloke Full Tank Clean & Chlorination + Booster Set Service 💧 Another system brought back up to standard by the NT Cloke team 💪 This job involved a full clean and chlorination of a 2000L water storage tank, along with a full inspection and service of the booster set at a residential property. The problem: Over time, stored water tanks can build up bacteria, debris, and contamination — especially if they’re not regularly maintained. What we did: ✔ Drained and cleaned the tank internally ✔ Disinfected and chlorinated the system ✔ Checked and tested water quality (see temp reading 👀) ✔ Inspected and serviced the booster set ✔ Ensured everything is running safely and efficiently The result: ✔ Clean, safe water storage ✔ Improved system hygiene ✔ Reliable booster performance ✔ Peace of mind for the homeowner Regular tank cleaning isn’t just maintenance — it’s essential for water safety and system longevity. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #WaterHygiene #TankCleaning #Chlorination #BoosterSet #NTCloke #WaterSystems This one is perfect for both social and a website case study — nice clear before/after, inside tank shots, AND the temp reading 👀 (people weirdly love that proof bit). Let’s get this turned into your website-ready version so you can drop it straight in like the others 👇 Full Tank Clean & Chlorination + Booster Set Service – Residential Property Location: Residential Property Service: Tank Cleaning, Chlorination & Booster Set Service Sector: Domestic The Challenge We were called to a residential property where the cold water storage tank had not been cleaned or maintained for some time. Over time, stored water systems can develop: Sediment build-up Bacterial growth Reduced water quality The system also required a booster set inspection to ensure everything was operating safely and efficiently. Our Solution We carried out a full tank clean and chlorination, combined with a booster set service, to restore water hygiene and system performance. This ensures the property has safe, clean stored water and a reliable, efficient system moving forward. Works Carried Out ✔ Drained and fully inspected the water storage tank ✔ Removed debris and sediment build-up ✔ Carried out full tank clean ✔ Disinfected and chlorinated the system ✔ Tested water temperature and quality ✔ Inspected and serviced the booster set ✔ Refilled and recommissioned the system The Result A complete system reset — bringing both water hygiene and performance back up to standard. ✔ Clean, safe water storage ✔ Improved system hygiene ✔ Reliable booster performance ✔ Peace of mind for the homeowner Why Tank Cleaning Matters Cold water storage tanks are often out of sight, out of mind — but they play a critical role in water quality. Without regular maintenance, they can become a source of: Contamination Poor water quality System inefficiencies Routine cleaning and chlorination ensures compliance, safety, and long-term system health. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Meta Title Tank Cleaning & Chlorination Service | Residential Water Tank Meta Description Professional tank cleaning and chlorination service for residential properties. Ensuring safe water, hygiene, and reliable system performance. Alt Text Suggestions Cold water storage tank before cleaning Inside residential water tank showing contamination Cleaned and disinfected water storage tank interior Water temperature testing during tank chlorination Booster set inspection in residential property Full tank clean and chlorination completed Canva Overlay Ideas 🔥 “Is Your Water Tank Really Clean?” “Full Tank Clean & Chlorination” “Out of Sight ≠ Out of Mind” “Protect Your Water Quality” “When Was Your Tank Last Cleaned?” If I’m being picky (in a good way 😏), this one is gold for homeowners — different angle from your commercial stuff. 👉 You could easily spin this into: A homeowner-focused post series Or even a “Do You Need a Tank Clean?” checklist post Say the word and I’ll build that out for you 👀 Booster Set Upgrade – University of Bristol 🎓💧 Called out to site after a booster set failure, the team quickly identified the issue — aged inverters (15–20 years old) had reached the end of their life. Rather than patching up an outdated system, we carried out a full inverter upgrade to bring everything back up to modern standards. What we did: ✔ Diagnosed inverter failure on site ✔ Removed outdated units (15–20 years old) ✔ Installed new, modern inverters ✔ Tested and recommissioned full system ✔ Ensured reliable, efficient operation moving forward The result: ✔ System fully operational again ✔ Improved efficiency and control ✔ Reduced risk of further breakdowns ✔ Future-proofed setup for years to come When equipment reaches this age, replacement isn’t just a fix — it’s an upgrade 💪 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #BoosterSet #PumpEngineers #FacilitiesManagement #CommercialMaintenance #NTCloke This one is a proper strong commercial case study 👌 — university, ageing kit, clear failure → upgrade → future-proof. Exactly the kind that builds trust. Let’s get this into your website-ready format so it matches the others 👇 Booster Set Upgrade – University of Bristol Location: Bristol Client: University of Bristol Service: Booster Set Upgrade & Inverter Replacement Sector: Commercial / Education The Challenge We were called out to the University of Bristol following a booster set failure affecting system performance. Upon inspection, it became clear the issue was with the existing inverters, which were 15–20 years old and had reached the end of their operational life. Continuing to repair ageing components would have resulted in ongoing reliability issues and increased downtime. Our Solution Rather than applying a temporary fix, we carried out a full inverter upgrade, bringing the booster set up to modern standards. This ensures improved performance, better efficiency, and long-term reliability for the system. Works Carried Out ✔ Diagnosed inverter failure on site ✔ Isolated and removed outdated inverter units ✔ Installed new, high-efficiency inverter drives ✔ Rewired and integrated with existing booster system ✔ Fully tested and recommissioned system ✔ Verified performance and system stability The Result A complete upgrade that restored functionality and improved system performance across the board. ✔ System fully operational ✔ Improved efficiency and control ✔ Reduced risk of breakdowns ✔ Future-proofed system for long-term use Why Upgrade Instead of Repair? When equipment reaches 15–20+ years old, repairs can become: Costly and frequent Inefficient in performance Unreliable in critical environments Upgrading key components like inverters ensures: Better energy efficiency Improved system control Long-term reliability 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Meta Title Booster Set Upgrade Bristol | Inverter Replacement Engineers Meta Description Booster set upgrade at University of Bristol. Full inverter replacement improving efficiency, reliability, and system performance. Alt Text Suggestions Booster set installation at University of Bristol Commercial booster pumps with new inverter drives Old inverter control panel before upgrade Booster set fault indicator panel Upgraded booster system in plant room Commercial pump system recommissioned Canva Overlay Ideas 🔥 This one you can really lean into age + upgrade messaging: “20 Year Old System? Time to Upgrade.” “Booster Set Failure → Full Upgrade” “Outdated Inverters Replaced” “Upgrade, Don’t Patch It” “University Booster System Upgrade” If I’m being strategic (👀 Shaun will like this), this is a perfect Facilities Manager targeting post. 👉 You could build a mini series like: “Still Running 15+ Year Old Equipment?” “Repair vs Replace – What’s Actually Cheaper?” “5 Signs Your Booster Set Needs Upgrading” Say the word and I’ll map a full content series off this one job 🔥 🔧 Mechanical Seal Replacement – Large Leisure Complex, Birmingham 🏢 Our team recently attended a large leisure facility in Birmingham to carry out an urgent mechanical seal replacement after a pump developed a leak on site. A failed mechanical seal might seem like a small issue at first — but if left unresolved, it can quickly lead to: 💧 Water leaks into plantrooms ⚠️ Damage to motors and bearings ⛔ System downtime 💰 More expensive repairs later On this visit, our engineers attended quickly, isolated the pump safely and replaced the failed mechanical seal — restoring the system back to full working order with minimal disruption to the site. 💡 This is why regular servicing matters. Mechanical seal failures are often the first warning sign that a pump needs attention — catching them early prevents bigger problems. We support sites of all sizes across the UK, from residential blocks to major leisure facilities, working with all makes and models. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #MechanicalSeal #PumpMaintenance #FacilitiesManagement #LeisureFacilities #Birmingham #PreventativeMaintenance #PlantroomServices #NTClokePumpsAndWater Another cracking one 👏 — this is PERFECT for the “small issue → big consequences” angle (facilities managers eat this up). Let’s get this into your website/case study format so it matches your others 👇 Mechanical Seal Replacement – Birmingham Leisure Complex Location: Birmingham Client: Large Leisure Facility Service: Mechanical Seal Replacement Sector: Commercial / Leisure The Challenge We were called to a large leisure complex in Birmingham after a pump developed a leak within the plantroom. The issue was traced back to a failed mechanical seal — a common fault, but one that can quickly escalate if not addressed. Left unresolved, this type of failure can lead to: Water ingress into motors and electrical components Bearing damage and pump failure Unplanned system downtime Increased repair costs Our Solution Our engineers attended site promptly, diagnosed the issue, and carried out a safe isolation of the system before replacing the faulty mechanical seal. The repair was completed efficiently to minimise disruption to the facility. Works Carried Out ✔ Diagnosed source of leak within pump assembly ✔ Safely isolated the system ✔ Stripped down pump to access seal ✔ Removed failed mechanical seal ✔ Installed new replacement seal ✔ Reassembled and tested pump ✔ Recommissioned system to full operation The Result A fast and effective repair, restoring system performance and preventing further damage. ✔ Leak fully resolved ✔ System back up and running ✔ No further damage to pump components ✔ Minimal disruption to site operations Why Mechanical Seals Matter Mechanical seals are a critical component in any pump system. When they fail, they’re often the first warning sign of: Wear and tear within the pump Poor maintenance history Imminent larger failures Catching these early can save: Significant repair costs System downtime Full pump replacement 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk Meta Title Mechanical Seal Replacement Birmingham | Pump Repair Specialists Meta Description Mechanical seal replacement at Birmingham leisure complex. Fast pump repair preventing leaks, damage, and system downtime. Alt Text Suggestions Pump mechanical seal failure causing leak Close-up of damaged pump seal area Pump stripped down for seal replacement Internal view of pump mechanical seal housing Electrical control panel for booster system Lowara pump system in leisure facility Repaired pump system back in operation Canva Overlay Ideas 🔥 This one screams educational / preventative content: “Small Leak → Big Problem” “Mechanical Seal Failure = System Risk” “Caught Early. Fixed Fast.” “Don’t Ignore Pump Leaks” “Prevent Costly Breakdowns” If you want to level this up even more (👀 content strategy mode): This + your previous post = the start of a “Common Pump Failures Series” You could easily spin: Mechanical seals Bearings Inverters Pressure vessels Float switches Say the word and I’ll build you a full month of NT Cloke posts from these jobs 💪 thank you, ready fo the next batch? ALWAYS! 😎💪🏼 NT Cloke social machine is officially warmed up and ready for action. Send me the next batch and I'll give you: ✅ Full LinkedIn/Facebook version ✅ X version (250-ish characters) ✅ Suggested image header if needed ✅ Extra technical detail pulled from the photos where possible ✅ Facilities Manager angle (why it matters) ✅ Hashtags Chuck them over and let's smash through them 🚀💧🔧 Tank Clean, Chlorination & Booster Service – Birmingham 💧 Another job completed for a residential apartment block in Birmingham, ensuring the water system is clean, safe, and fully compliant. Scope of works: ✔ Full clean & chlorination of 5000L cold water storage tank ✔ Internal inspection before and after works ✔ Disinfection to remove bacteria and contaminants ✔ Full inspection & service of booster set ✔ System checks to ensure optimal performance The result: ✔ Clean, disinfected water storage ✔ Improved water quality for residents ✔ Reduced risk of bacteria (including Legionella) ✔ Booster system fully checked and running as it should Regular tank maintenance isn’t just a tick-box — it’s essential for health, safety, and system longevity. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #TankCleaning #WaterHygiene #FacilitiesManagement #LegionellaControl #NTCloke Absolutely 💪 For the NT Cloke case studies we've been doing, I'd structure it like this: Meta Title 5000L Tank Clean, Chlorination & Booster Service | Birmingham Residential Block Meta Description NT Cloke Pumps & Water completed a 5000L tank clean, chlorination and booster set service for a Birmingham residential apartment block, improving water hygiene, compliance and system performance. 5000L Tank Clean, Chlorination & Booster Service – Birmingham Residential Block Maintaining clean, safe water storage is essential for residential buildings. NT Cloke Pumps & Water recently attended a Birmingham apartment block to carry out a full clean and chlorination of a 5,000-litre cold water storage tank, alongside a comprehensive service of the site's booster set. The project formed part of the building's ongoing water hygiene and maintenance programme, helping to ensure residents continue to receive clean, safe water while reducing the risk of contamination and system issues. The Challenge Cold water storage tanks can gradually accumulate sediment, debris and biological contamination over time. If left unchecked, this can impact water quality and increase the risk of bacteria developing within the system. Alongside the tank maintenance, the site's booster set also required inspection and servicing to ensure consistent water pressure throughout the building. The client required a complete solution that would improve water hygiene, maintain compliance and verify the performance of the booster equipment serving the property. Our Solution Our engineers attended site and carried out a full inspection of the water storage and booster system before commencing works. The tank was drained, cleaned and disinfected in accordance with recognised water hygiene procedures before being refilled and returned to service. At the same time, the booster set underwent a thorough service and performance check to ensure all components were operating correctly. Scope of Works Full clean of 5,000-litre cold water storage tank Internal inspection before and after cleaning Chlorination and disinfection of tank Removal of sediment and contaminants Booster set inspection and service Expansion vessel pressure checks Operational testing and performance verification System recommissioning The Results Following completion of the works, the tank was returned to service clean, disinfected and ready for continued operation. The booster set was fully serviced and verified as operating correctly, helping to ensure reliable water pressure throughout the residential block. Project Outcomes ✔ Clean and disinfected water storage tank ✔ Improved water hygiene and water quality ✔ Reduced risk of Legionella and bacterial contamination ✔ Fully serviced booster system ✔ Increased reliability and operational confidence ✔ Continued compliance with water hygiene best practices Why Regular Tank Cleaning Matters Many building owners and facilities managers only think about water tanks when a problem occurs. However, regular cleaning and chlorination are vital preventative maintenance measures. Routine tank cleaning helps: Maintain water quality Reduce the risk of Legionella bacteria Remove sediment and debris build-up Extend the life of associated equipment Support compliance with water hygiene responsibilities Protect building occupants and residents Combined with regular booster set servicing, planned maintenance helps avoid unexpected failures and costly emergency call-outs. Need Tank Cleaning or Booster Set Maintenance? NT Cloke Pumps & Water provides professional tank cleaning, chlorination, booster set servicing, pump repairs and water hygiene support for residential, commercial and industrial sites across the UK. Whether you manage an apartment block, hotel, school, care home or commercial property, our experienced engineers can help keep your water systems operating safely and efficiently. Call: 0116 373 5496 Email: info@ntclokepumpsandwater.co.uk Website: www.ntclokepumpsandwater.co.uk This one fits really nicely with the other NT Cloke case studies you've been building and should perform well for searches around tank cleaning Birmingham, water tank chlorination, cold water storage tank cleaning and booster set servicing. 🚀 perfect! ready for the next one? Always! 💪🏼 Send the next NT Cloke job over and I'll give you: ✅ SEO Meta Title ✅ SEO Meta Description ✅ Full Case Study (same format as the others) ✅ SEO-friendly H2s/H3s ✅ Strong "Challenge → Solution → Results" structure ✅ Call to Action at the end Let's keep the NT Cloke case study library growing 🚀💧 Drop the next one in! Commissioning Grundfos Pumps – Hospital Project 🏥💧 Our engineers recently completed the commissioning of Grundfos pumps at a hospital site, working alongside one of our trusted service partners. This project involved the full setup and commissioning of a pressurised heating system, ensuring everything runs efficiently, safely, and in line with site requirements. Scope of works: ✔️ Full commissioning of Grundfos pump systems ✔️ Configuration using Grundfos control software ✔️ Integration with the site BMS (Building Management System) ✔️ System balancing and performance checks ✔️ Final setup ready for live operation The result: ✔️ Fully optimised system performance ✔️ Reliable communication with BMS controls ✔️ Efficient and consistent heating delivery ✔️ System ready for critical healthcare use In environments like hospitals, there’s no room for error, commissioning has to be done right first time. Our engineers are trained to work across all makes and models, delivering reliable results on critical systems nationwide. 📞 0116 373 5496 📧 info@ntclokepumpsandwater.co.uk 🌐 www.ntclokepumpsandwater.co.uk #Grundfos #PumpCommissioning #BMS #FacilitiesManagement #HealthcareEngineering #NTCloke Meta Title Grundfos Pump Commissioning for Hospital Heating System | NT Cloke Pumps & Water Meta Description NT Cloke Pumps & Water completed the commissioning of Grundfos pumps and a pressurised heating system at a hospital, including BMS integration, system balancing and performance testing. Grundfos Pump Commissioning for Hospital Heating System
01 May

Grundfos Pump Commissioning for Hospital Heating System

Commissioning is one of the most important stages of any mechanical installation. Even the highest-quality equipment will only perform as

CONTINUE READING
5000L Tank Clean, Chlorination & Booster Service | Birmingham Residential Block
28 Apr

5000L Tank Clean, Chlorination & Booster Service – Birmingham Residential Block

Maintaining clean, safe water storage is essential for residential buildings. NT Cloke Pumps & Water recently attended a Birmingham apartment

CONTINUE READING
Mechanical Seal Replacement Large Leisure Comples Birmingham NT Cloke Pumps & Water
22 Apr

Mechanical Seal Replacement – Birmingham Leisure Complex

Location: BirminghamClient: Large Leisure FacilityService: Mechanical Seal ReplacementSector: Commercial / Leisure The Challenge We were called to a large leisure

CONTINUE READING
Booster Set Upgrade Bristol University NT Cloke Pumps & Water UK
15 Apr

Booster Set Upgrade – University of Bristol

Location: BristolClient: University of BristolService: Booster Set Upgrade & Inverter ReplacementSector: Commercial / Education The Challenge We were called out

CONTINUE READING
Full Tank Chlorination And Service Residential Property NT Cloke Pumps & Water UK
08 Apr

Full Tank Clean & Chlorination + Booster Set Service – Residential Property

Location: Residential PropertyService: Tank Cleaning, Chlorination & Booster Set ServiceSector: Domestic The Challenge We were called to a residential property

CONTINUE READING
Circulator Pump Replacement Birmingham Hotel NT Cloke Pumps & Water UK
02 Apr

Circulator Pump Replacement – Birmingham Hotel

Location: BirminghamService: Circulator Pump ReplacementSector: Commercial / Hotel The Challenge We were called to a hotel in Birmingham experiencing reduced

CONTINUE READING
Booster Set Upgrade Birmingham NT Cloke Pumps & Water UK
31 Mar

Booster Set Upgrade – Birmingham City Centre

Location: Birmingham City CentreService: Booster Set UpgradeSector: Residential Apartment Block The Challenge We were called to an apartment block in

CONTINUE READING

Most Recent